油泥对自动搅拌一体车的影响都有哪些？_公司新闻_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

油泥对自动搅拌一体车的影响都有哪些？

所属分类：公司新闻发布时间：2020-11-11 来源：http://www.shanqijituan.cn/ 浏览量：0

油泥对自动搅拌一体车的影响都有哪些，今天我们来了解一下。

What are the effects of sludge on the automatic mixer truck? Let's have a look at it today.

自动搅拌一体车通常用于建筑行业，使用时无法避免污泥。这是污泥如何影响它。

Automatic mixer truck is usually used in construction industry, and sludge cannot be avoided. This is how the sludge affects it.

1.发动机尾气排放降低，火花塞，氧传感器和三效催化剂的使用寿命也缩短。

1. The engine exhaust emission is reduced, and the service life of spark plug, oxygen sensor and three-way catalyst is also shortened.

2.发动机功率降低，加速不平稳，油耗增加。

2. The engine power is reduced, the acceleration is not stable, and the fuel consumption is increased.

3.自动搅拌一体车的冷启动很困难。冷车的怠速无法达到规定的速度。在严重的情况下，冷车的怠速将被关闭，并且热车之后的怠速低。

3. It is very difficult to start the automatic mixer. The idle speed of the cold car cannot reach the specified speed. In severe cases, the idle speed of the cold car will be turned off, and the idle speed after the hot car will be low.

4.积碳也会使发动机的活塞环卡住，影响活塞环的密封性能，自动搅拌一体车的油耗会增加，导致发动机燃烧油，缩短使用寿命引擎。

4. Carbon deposition will also cause the piston ring of the engine to jam and affect the sealing performance of the piston ring. The fuel consumption of the automatic mixing vehicle will increase, resulting in the engine burning oil and shortening the service life of the engine.

以上是污泥对自动搅拌一体车的影响，因此在使用自动搅拌一体车后应进行清洗，以防止污泥堆积。

The above is the impact of sludge on the automatic mixer truck, so it should be cleaned after using the automatic mixer to prevent sludge accumulation.

自动搅拌一体车的日常清洁步骤

Daily cleaning steps of automatic mixer truck

每天必须清洗自动搅拌一体车，自动搅拌一体车凝固，如果需要很长时间，会导致腐蚀。如果长时间不干净，汽车会变得越来越重。以下是每个人的日常清洁程序。

The automatic mixer truck must be cleaned every day. If it takes a long time, it will cause corrosion. If it is not clean for a long time, the car will become heavier and heavier. Here is everyone's daily cleaning procedure.

1.每次灌装前用水冲洗进料口，以便在灌装过程中保持进料口湿润;

1. Flush the feed inlet with water before each filling, so as to keep the feed inlet moist during the filling process;

2.在装载的同时，将装有车辆的洗涤水箱装满水;

2. At the same time of loading, fill the washing water tank of the vehicle with water;

3.充电后，冲洗进料口，清洁进料口附近的混凝土;

3. After charging, flush the feed port and clean the concrete near the feed inlet;

4.在施工现场卸货后，冲洗排水罐，然后在自动搅拌一体车中加入30-40L洗涤水;当车辆返回时，保持混凝土罐缓慢旋转;

4. After unloading at the construction site, wash the drainage tank, and then add 30-40l washing water into the automatic mixing truck; when the vehicle returns, keep the concrete tank slowly rotating;

5.记得在下次装货前将污水放入自动混凝土搅拌罐中;

5. Remember to put the sewage into the automatic concrete mixing tank before the next loading;

6.每天彻底清洁自动搅拌一体车搅拌槽和工作周围的进出口，确保没有水泥和混凝土结块。

6. Thoroughly clean the mixing tank of the automatic mixer truck and the inlet and outlet around the work area every day to ensure that there is no cement and concrete caking.

自动搅拌一体车必须注意正常清洁。如果长时间不清洁，会对车辆造成损坏，大大缩短自动自动搅拌一体车的使用寿命。

Attention must be paid to the normal cleaning of the automatic mixer. If it is not cleaned for a long time, it will damage the vehicle and greatly shorten the service life of the automatic mixing vehicle.

自动搅拌一体车的油泥影响问题介绍就是这样了，希望对你有帮助。

This is the introduction of the sludge influence of the automatic mixer. I hope it can help you.

上一页：驾驶自动搅拌一体机需要培训内容有哪些？下一页：多功能搅拌车忽然不工作了是什么原因

热门产品 / HOT PRODUCT