自动上料水泥搅拌车的操作注意事项_公司新闻_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

自动上料水泥搅拌车的操作注意事项

所属分类：公司新闻发布时间：2022-09-28 来源：http://www.shanqijituan.cn/ 浏览量：0

自动上料水泥搅拌车是一款广范应用于城市建设道路、乡间修路、桥梁、房屋、水利工程、基建工程、搅拌站等项目的机械设备，特别是近几年我国乡村的快速发展，更是给自动上料水泥搅拌车发展的空间，该设备凭借快捷效率高的优势，占据了混凝土施工工程的核心。今天福瑞得自上料混凝土搅拌车厂家教给大家的是自动上料水泥搅拌车的操作注意事项，希望大家仔细阅读。

The automatic feeding cement mixer is a mechanical equipment widely used in urban construction roads, rural road construction, bridges, houses, water conservancy projects, infrastructure projects, mixing stations and other projects. Especially in recent years, the rapid development of rural areas in China provides space for the development of automatic feeding cement mixers. With its advantages of fast and high efficiency, the equipment occupies the core of concrete construction projects. Today, what Fred taught you from the concrete mixer factory is the operation precautions of the automatic feeding cement mixer. I hope you can read it carefully.

3.jpg

1、在起动自动上料水泥搅拌车之前，应把搅拌筒操作手柄放在“停止”位置。

1. Before starting the automatic feeding cement mixer, put the operating handle of the mixing drum at the "stop" position.

2、自动上料水泥搅拌车起动发动机后，应使搅拌筒在低速下转动10分钟左右，使液压油温升到20℃以上后方可工作。

2. After the engine of the automatic feeding cement mixer is started, the mixing drum shall be rotated at low speed for about 10 minutes to make the hydraulic oil temperature rise to above 20 ℃ before operation.

3、自动上料水泥搅拌车在运输混凝土时，要保证滑斗放置牢固，防止因松动造成摆动，在行进中打伤行人或影响其它车辆正常运行。

3. When transporting concrete, the automatic loading cement mixer shall ensure that the sliding bucket is firmly placed to prevent swinging due to looseness, injuring pedestrians or affecting the normal operation of other vehicles.

5、自动上料水泥搅拌车装运搅拌好的混凝土时，搅拌筒转速为2-10转/分，在运输过程中，平坦路面上搅拌筒转速保证在2-3转/分，行驶在侧倾坡度大于50的路面，或左右晃动较大的路面时，应停止搅拌旋转，待路况好转后再恢复搅拌旋转。

5. When the automatic loading cement mixer truck is used to transport the mixed concrete, the rotating speed of the mixing drum is 2-10 rpm. During the transportation, the rotating speed of the mixing drum on the flat road shall be guaranteed to be 2-3 rpm. When driving on the road with a side slope greater than 50, or the road with a large shake from left to right, the mixing rotation shall be stopped, and the mixing rotation shall be resumed after the road conditions improve.

6、自动上料水泥搅拌车运送混凝土的时间不能超过搅拌站规定的时间。运送混凝土途中，搅拌筒不得长时间停转，以防混凝土产生离析现象。司机应时常观察混凝土情况，发现异常及时通报调度室，申请做出处理。

6. The time for automatic loading cement mixer to transport concrete shall not exceed the time specified by the mixing station. During the transportation of concrete, the mixing drum shall not be stopped for a long time to prevent segregation of concrete. The driver shall always observe the concrete condition, report to the dispatching room in time in case of any abnormality, and apply for handling.

7、自动上料搅拌车运送混凝土塌落度不得低于8cm。从混凝土入罐到排出，气温高时不得超过2小时排出，阴雨天气温度低时，不得超过2.5小时。

7. The slump of concrete transported by automatic feeding mixer shall not be less than 8cm. From the time of concrete entering the tank to discharging, it shall not exceed 2 hours when the temperature is high, and it shall not exceed 2.5 hours when the temperature is low in rainy days.

8、自动上料水泥搅拌车在排出混凝土之前，应使搅拌筒在10-12转/分的转速下转动1分钟，再进行排料。

8. Before discharging the concrete, the automatic loading cement mixer shall rotate the mixing drum for 1 minute at the speed of 10-12 rpm before discharging.

9、出料完毕后，应立即用随车的软管放水将进料口、出料斗及出料溜槽等部位冲洗干净，排去粘结在车身各处的污物及残留混凝土，再向搅拌筒内注水150-200L的清水，在返回途中要让搅拌筒慢速转动，以清洗内壁，避免残余料渣附在筒壁和搅拌叶上，并在再一次装料前将这些水放掉。

9. After discharging, immediately flush the feeding inlet, discharge hopper, discharge chute and other parts with the hose attached to the vehicle, drain the dirt and residual concrete bonded to the vehicle body, and then inject 150-200L clean water into the mixing drum. On the way back, let the mixing drum rotate slowly to clean the inner wall to avoid the residual slag adhering to the drum wall and mixing blade, and drain the water before re loading.

10、自动上料水泥搅拌车运送混凝土时，发动机转速在1000-1400转/分范围内工作，以使发动机有大扭距，在运送混凝土过程中，车速不得超过40km/h，以保行车。

10. When the automatic feeding cement mixer is used to transport concrete, the engine speed shall be within the range of 1000-1400 rpm to make the engine have a large torque. During the concrete transportation, the speed shall not exceed 40km/h to ensure driving.

11、自动上料水泥搅拌车在水泵工作时，禁止空转，连续使用时不要超过15分钟。

11. When the water pump of the automatic feeding cement mixer is working, it is prohibited to idle, and the continuous use shall not exceed 15 minutes.

另外，自上料混凝土搅拌车厂家提醒大家在自动上料水泥搅拌车工作完毕后，应及时把搅拌筒内部和车身清洗干净，不能使剩余的混凝土留在筒内哦。

In addition, the manufacturer of the loading concrete mixer reminds everyone that after the automatic loading cement mixer is completed, the inside and body of the mixing drum should be cleaned in time, and the remaining concrete should not be left in the drum.

上一页：自动上料水泥搅拌车工作注意事项下一页：小型混凝土搅拌车的刹车技巧。

热门产品 / HOT PRODUCT