操作自上料搅拌车需要注意的要点有哪些？_公司新闻_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

操作自上料搅拌车需要注意的要点有哪些？

所属分类：公司新闻发布时间：2022-03-09 来源：http://www.shanqijituan.cn/ 浏览量：0

自上料搅拌车放料时，水箱的水要尽量保持满状态。冬天应该排干净水，防止冻裂。下面跟着小编一起学习下自上料搅拌车的操作要点。

When discharging from the loading mixer, the water tank shall be kept as full as possible. Water should be drained in winter to prevent frost cracking. Now follow Xiaobian to learn the operation points of self loading mixer.

1、搅拌车在水泵作业时，制止空转，接连运用时不要超越15分钟。

1. When the mixer truck is working with the water pump, stop idling and do not exceed 15 minutes in continuous operation.

2、搅拌车放料前先把出料斗溜槽打湿。放料时把车尽量停在平地上放料。

2. Wet the chute of the discharge hopper before discharging. When discharging, park the vehicle on the flat ground as far as possible.

3、卸料不要粗心和放料工打好联系。放料时尽量自己看着，免得放料工乱操作放料操作杆，每次罐子正反转中间位子时尽量停一下，维护减速机，托轮等。与放料工打好联系，卸料时也不要睡的太熟，万一工人闹情绪，把你车子放到工地不转罐子，形成闷罐就麻烦了。

3. Don't be careless in unloading and make good contact with the discharging worker. Try to watch by yourself when discharging, so as to avoid the discharging operator operating the discharging lever disorderly. Try to stop every time the tank is in the middle of the reverse direction, and maintain the reducer, supporting wheel, etc. Make good contact with the discharging worker and don't sleep too well during unloading. In case the worker is in a mood, put your car on the construction site and don't turn the can, it will be troublesome to form a stuffy can.

4、搅拌车水箱的水量要经常保持装满，以备急用，冬天停机后，应将水箱、水泵、水管、拌和筒内的水放净，并停放在向阳、不积水的地方，避免冻坏机械。

4. In winter, the mixer shall be kept in the water tank, which shall not be filled with cold water, and the water pump shall be kept in the place where the mixer is shut down and ready for use. In addition, the water tank shall be kept in the place where the mixer is shut down in winter.

5、卸料前让拌和罐全速作业一两分钟。让混凝土充沛拌和，必要时可以加一些水，让混凝土拌和得更均匀，也方便卸料。

5. Allow the mixing tank to operate at full speed for one or two minutes before unloading. Let the concrete be fully mixed. If necessary, add some water to make the concrete mix more evenly and facilitate unloading.

6、搅拌车作业结束，应把拌和筒内部和车身清洗干净，不能使剩下的混凝土留在筒内。

6. After the operation of the mixer truck is completed, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.

7、拌和罐一定要细心地冲刷干净。洗罐子时一定要细心的冲刷干净，并把水反复的正反转两次，再放出来，然后一趟时把水箱的水悉数放进罐子，再回到站加水完全清洗罐子。

7. The mixing tank must be washed carefully. When washing the jar, be sure to wash it carefully, and repeat the positive and negative rotation of the water twice, and then release it. Then put all the water in the water tank into the jar, and then return to the station to add water to completely clean the jar.

8、搅拌车在冬天应及时装置保温套，并运用防冻液对搅拌车加以维护，根据气候改变更换燃油标号，确保机械的正常运用。

8. In winter, the mixing truck shall be equipped with insulation sleeve in time, and the mixing truck shall be maintained with antifreeze. The fuel grade shall be changed according to the climate change to ensure the normal operation of the machinery.

9、在检查、修补搅拌车液压传动部分时，应使发动机和液压泵在没有压力的情况下进行。

9. When inspecting and repairing the hydraulic transmission part of the mixer truck, the engine and hydraulic pump shall be operated without pressure.

10、在调整混凝土自动上料搅拌车各部间隙、行程、压力时，应由专职检查员检查赞同；更换机件时，一定要由部长或主管司理签字，否则出现问题后追究有关人员职责。

10. When adjusting the clearance, stroke and pressure of each part of the automatic concrete feeding mixer, it shall be checked and approved by the full-time inspector; When replacing the machine parts, it must be signed by the minister or the competent manager, otherwise the responsibilities of relevant personnel will be investigated in case of problems.

以上就是为大家介绍的有关全自动上料搅拌车的详细介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.shanqijituan.com/

The above is a detailed introduction to the automatic feeding mixer truck. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.shanqijituan.com/

上一页：经常打死水泥搅拌车方向盘很伤车！下一页：多功能的搅拌车能在哪些路况下施工？

热门产品 / HOT PRODUCT