搅拌机试运转时应该注意什么？_ 行业动态_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

搅拌机试运转时应该注意什么？

所属分类：行业动态发布时间：2021-04-13 来源：http://www.shanqijituan.cn/ 浏览量：0

客户在购买搅拌机后，都要先空载试运转一下，看看搅拌机是否可以正常运转，才能正式使用，但是在试运转时也需要注意很多注意事项，小编给您总结了以下几点。

After the customer purchases the mixer, they all need to have a no-load test run to see if the mixer can operate normally before it can be used formally. However, they also need to pay attention to a lot of precautions during the test run. The editor summarizes the following points for you.

搅拌机空载试运转注意事项：

Precautions for no-load commissioning of mixer:

1、混凝土搅拌机电动机应运动试验，观察是否正常。

1. The motor of concrete mixer should be tested first to see if it is normal.

2、启动搅拌电动机，皮带的旋转方向应与标注的尖头方向一致，若方向不一致时，应改变电流接线。

2. When starting the mixing motor, the rotation direction of the belt should be consistent with the marked tip direction. If the direction is inconsistent, the current wiring should be changed.

3、启动卷扬电动机的提升料斗时，要检查料斗升降过程以及上、下限位是否可靠。

3. When starting the lifting hopper of the winch motor, it is necessary to check the lifting process of the hopper and whether the upper and lower limits are reliable.

4、启动卸料装置，卸料门开闭应要保持准确到位。

4. When the unloading device is started, the opening and closing of the unloading door should be kept in place.

5、点动水泵电动机，检查旋转方向。

5. Jog the pump motor and check the rotation direction.

6、拧开水泵加水螺塞灌入引水时，要使水充满泵腔以及进水管，直能吸水为止，然后再把加水螺塞拧紧。

6. Screw on the water plug of the water pump to fill the pump cavity and the water inlet pipe until it can absorb water, and then tighten the water plug.

很多用户在对刚购买回来的搅拌一体机都是直接使用，根本不去检查，也不注意对于新机搅拌机试运机的重要性，大多数搅拌一体机操作用戾都觉的检查太麻烦。用户的这种想法是不对了。对于新机试用前的准备工作也是每一个操作使用混凝土搅拌机的工作人员都不可忽视的。检查并不是一件麻烦的事，检查是为了减少更多的麻烦所必须的工作。

Many users just bought back in the mixing machine are directly used, simply do not check, also do not pay attention to the importance of the new machine mixer trial run machine, most of the mixing machine operation with Li feel that the inspection is too troublesome. The user's idea is wrong. For the new machine before the trial preparation work is also every operation of the use of concrete mixer staff can not be ignored. Inspection is not a troublesome thing. Inspection is a necessary work to reduce more troubles.

上一页：全自动上料搅拌一体车为什么会熄火？下一页：搅拌一体机的容积如何选择？

热门产品 / HOT PRODUCT