自上料搅拌车的日常的检查“硬核”问题！_ 行业动态_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

自上料搅拌车的日常的检查“硬核”问题！

所属分类：行业动态发布时间：2022-05-20 来源：http://www.shanqijituan.cn/ 浏览量：0

1、控制气压紧固接头.罐体内应该打进多少的气压，这个在出厂的时候已经设定好，不需自己调节。如果遇上特殊情况非要调节，建议压力控制在3.5Mpa左右，压力太大容易爆管。另外，新的自上料搅拌车以及日常使用中，要对管路接口的地方随时紧固，防止落。

1. Tighten the connector for the control air pressure How much air pressure should be injected into the tank? This has been set at the time of delivery and does not need to be adjusted by yourself. If it is necessary to adjust in case of special circumstances, it is recommended to control the pressure at about 3.5Mpa. If the pressure is too high, it is easy to burst the pipe. In addition, for the new self loading mixer and in daily use, the place of pipeline interface shall be fastened at any time to prevent falling.

2、罐车加水流程. 每种罐车加水处的布置都大同小异，一般都是水罐排气——加满水——关闭加水阀;在不用的情况下，将拨杆的位置放在中间。

2. Filling process of tank car The arrangement of the water filling place of each tank car is similar. Generally, the water tank is vented - filled with water - and the water filling valve is closed; When not in use, put the position of the paddle in the middle.

3、冬季排尽管内余水. 在冬季每天收车之后应该排尽水罐内和水管中的水，并在水管打入压缩空气吹尽各个管路中残留的水，防止因为结冰造成管路冻裂。水泥自上料搅拌车

3. Drain the remaining water in winter After the vehicle is collected every day in winter, the water in the water tank and the water pipe should be drained, and compressed air should be injected into the water pipe to blow out the residual water in each pipeline to prevent the pipeline from freezing and cracking due to icing. Cement self loading mixer

4、随车带上减水剂，减水剂是一种在维持混凝土坍落度不变的条件下，能减少拌合用水量的混凝土外加剂，随车携带，能对混凝土进行很好的调节。不过在加入减水剂的时候，一定要记得有商砼站化验室的人在场，否则混凝土质量强度不够，驾驶员要承担后果。

4. The water reducing agent is a kind of concrete admixture that can reduce the mixing water volume under the condition of maintaining the constant slump of concrete. It can be carried with the vehicle and adjust the concrete well. However, when adding water reducing agent, it must be remembered that there are people in the laboratory of commercial concrete station, otherwise the concrete quality and strength are not enough, and the driver will bear the consequences.

5、回厂检查罐内水量.每次出车任务完成回到站内的时候，检查储水罐内的水量，让水罐中的水随时处于满罐的状态，以备不时之需。

5. Return to the factory to check the water volume in the tank When returning to the station after the completion of each trip, check the water volume in the water storage tank to keep the water in the tank full at any time in case of emergency.

6、离厂前检查混凝土质量。可能会因为原料的不同，每一盘混凝土质量都会有变化。在装好混凝土离场时，一定要检查罐内混凝土的塌落度情况以及和易度，小心混凝土的提前凝结和混凝土分层沉淀。

6. Check the concrete quality before leaving the factory. The quality of each plate of concrete may change due to different raw materials. When leaving the site after loading the concrete, be sure to check the slump and workability of the concrete in the tank, and be careful of the early setting of the concrete and the layered precipitation of the concrete.

7、减少车辆行驶时间.混凝土运距一般在直径30范围以内，出车之前规划好路线以及车辆通行情况，尽量减少车辆在路上的时间。

7. Reduce vehicle travel time The concrete transportation distance is generally within 30 kilometers in diameter. The route and vehicle traffic shall be planned before driving to minimize the time of vehicles on the road.

8、减少损失先卸料.如果遇到人为因素或者不可抗因素，导致长时间无法卸料的情况，应随时查看罐内混凝土情况，一旦发现混凝土开始凝结。在报备负责人之后立刻进行卸料，以防整个罐体报废。自上料搅拌车

8. Reduce losses and unload first In case of failure to unload for a long time due to human factors or irresistible factors, check the concrete in the tank at any time. Once it is found that the concrete begins to set. Unload the material immediately after reporting to the person in charge to prevent the whole tank from being scrapped. Self loading mixer

9、随时需清洗.运营当中随时冲洗。在每次卸料之后，用罐车自己带水枪对罐口、叶片、进料口、罐体以及犄角旮旯进行冲洗，防止混凝土凝固之后越积越多，不好清理。

9. It needs to be cleaned at any time Flush at any time during operation. After each unloading, wash the tank mouth, blades, feed inlet, tank body and corners with the water gun of the tank truck to prevent the accumulation of concrete after solidification, which is difficult to clean.

10、收车之后清洗罐车。每天的运送任务结束之后，在罐内加入1立方米以上的清水，快速的旋转罐体进行清洗。有条件的公司，还可以在罐内加入石子，效果会更好。

10. Clean the tank car after collection. After the daily delivery task, add more than 1 cubic meter of clean water into the tank and quickly rotate the tank for cleaning. Conditional companies can also add stones into the tank, which will have a better effect.

本文的精彩内容中科聚峰混凝土搅拌车提供知识提供，本网站还有很多的精彩内容，更多的内容您可以点击进入：https://www.cnzkjf.com我们有专门的客服为您解答问题

In the wonderful content of this article, kejufeng concrete mixer provides knowledge. There are many wonderful contents on this website. You can click to enter more contents: https://www.cnzkjf.com We have special customer service to answer your questions

上一页：自上料搅拌车是理想的搅拌混合机械下一页：为什么小型混凝土搅拌车罐子用布包着

热门产品 / HOT PRODUCT