多功能搅拌车你真的了解吗？_公司新闻_新闻资讯_自动搅拌一体车_自动搅拌一体机

站内搜索

新闻资讯

公司新闻行业动态

热点

自动上料平口搅拌机多种方量可供选择

2022-12-23

混凝土自动上料搅拌车的功能有哪些？

2022-12-19

混凝土自动拌料车移动式可自行走户外施工

2022-12-16

自上料搅拌车企业这么多，买车的时候应该看哪方面？

2022-12-12

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

多功能搅拌车你真的了解吗？

所属分类：公司新闻发布时间：2020-06-16 来源：http://www.shanqijituan.cn/ 浏览量：0

搅拌车是一种特殊车辆，并不是所有会开车的司机都会开搅拌车，如果操作不当会引起翻车、液压泵、马达、减速机过快磨损甚出现严重后果。

The mixer is a special vehicle, not all drivers can drive the mixer, if the operation is not correct, it will cause the tipping, hydraulic pump, motor, reducer too fast wear and even serious consequences.

1．起动搅拌车之前，应把搅拌筒操作手柄放在“停止”位置。

1. Before starting the mixer, place the operating handle of the mixing drum in the "stop" position.

2．搅拌车起动发动机后，应使搅拌筒在低速下转动10分钟左右，使液压油温升到20℃以上后方可工作。

2. After the mixer truck starts the engine, the mixer drum shall be rotated at low speed for about 10 minutes, and the hydraulic oil temperature shall be raised above 20 ℃ before operation.

3．搅拌车在露天停放时，装料前应将搅拌筒反转，将积水和杂物排出，以保证混凝土的质量。

3. When the mixer truck is parked in the open air, the mixing drum shall be reversed before loading, and the accumulated water and sundries shall be discharged to ensure the quality of concrete.

4．搅拌车在运输混凝土时，要保证滑斗放置牢固，防止因松动造成摆动，在行进中打伤行人或影响其它车辆正常运行。

4. When transporting concrete, the mixer truck shall ensure that the sliding bucket is placed firmly to prevent swinging caused by loosening, hurting pedestrians or affecting the normal operation of other vehicles in the process of moving.

5. 搅拌车装运搅拌好的混凝土时，搅拌筒转速为2-10转/分，在运输过程中，平坦路面上搅拌筒转速保证在2-3转/分，行驶在侧倾坡度大于50的路面，或左右晃动较大的路面时，应停止搅拌旋转，待路况好转后再恢复搅拌旋转。

5. When the mixer truck loads the mixed concrete, the speed of the mixer drum shall be 2-10 rpm. During the transportation, the speed of the mixer drum shall be 2-3 rpm on the flat road surface. When driving on the road surface with a slope greater than 50, or the road surface with large left and right shaking, the mixing rotation shall be stopped, and the mixing rotation shall be resumed after the road condition is improved.

6. 多功能搅拌车运送混凝土的时间不能超过搅拌站规定的时间。运送混凝土途中，搅拌筒不得长时间停转，以防混凝土产生离析现象。司机应时常观察混凝土情况，发现异常及时通报调度室，申请做出处理。

6. The time for transporting concrete by multi-functional mixer shall not exceed the time specified by the mixing plant. During the transportation of concrete, the mixing drum shall not be stopped for a long time to prevent the concrete from segregation. The driver shall often observe the concrete condition, timely report to the dispatching room in case of any abnormality, and apply for handling.

7. 搅拌车车内装有混凝土时，在现场停滞时间不得超过1小时，如超时应立即要求现场负责人给予及时处理。

7. When the mixer truck is equipped with concrete, the dead time at the site shall not exceed 1 hour. If it exceeds the time limit, the person in charge of the site shall be required to deal with it in time.

8. 搅拌车运送混凝土塌落度不得低于8cm。从混凝土入罐到排出，气温高时不得超过2小时必须排出，阴雨天气温度低时，不得超过2.5小时。

8. The slump of concrete transported by mixer truck shall not be less than 8cm. From the time when the concrete is put into the tank to the time when it is discharged, it shall not be discharged for more than 2 hours when the temperature is high, and it shall not be discharged for more than 2.5 hours when the temperature is low in rainy days.

9. 搅拌车在排出混凝土之前，应使搅拌筒在10-12转/分的转速下转动1分钟，再进行排料。

9. Before discharging the concrete, the mixer shall rotate for 1 minute at the speed of 10-12 RPM before discharging.

10. 多功能搅拌车出料完毕，应立即用随车的软管放水将进料口、出料斗及出料溜槽等部位冲洗干净，排去粘结在车身各处的污物及残留混凝土，再向搅拌筒内注水150-200L的清水，在返回途中要让搅拌筒慢速转动，以清洗内壁，避免残余料渣附在筒壁和搅拌叶上，并在再一次装料前将这些水放掉。

ten After the discharge of the multi-functional mixer, immediately flush the inlet, outlet hopper, discharge chute and other parts with the hose attached to the mixer, remove the dirt and residual concrete stuck on the vehicle body, and then inject 150-200l clean water into the mixer. On the way back, let the mixer rotate slowly to clean the inner wall, and avoid the residual slag attached to the wall and mixing blade Drain the water before loading again.

这几点是比较重要的操作知识，如果想了解更多可以到山汽上去了解更多这方面的信息。

These are important operation knowledge. If you want to know more, you can go to the shanqi to learn more about this

上一页：自动搅拌一体机钢板易碎问题下一页：多功能搅拌车的操作你了解多少？

热门产品 / HOT PRODUCT